Product ID:G-4638 RED INSULATING VARNISH
MSDS Date:07/11/1988
FSC:5970
NIIN:00F039632
MSDS Number: BWXJP

RANBAR TECHNOLOGY INC

1114 WM FLINN HWY
GLENSHAW, PA 15116-5000
US

Emergency Phone: 412-486-1111

Info Phone: 412-486-1111

Preparer: PAUL R YINGST

Cage: 0TS14

RANBAR TECHNOLOGY INC

GLENSHAW, PA 15116 US

Telephone: 800-424-9300 (CHEMTREC)

Cage: 0TS14

MEDIUM ALIPHATIC NAPHTHA (AROMATIC 100), PARAFFIN-NAPTHANES

CAS: 64742-88-7

Fraction By Weight: 41%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

RED IRON OXIDE/IRON (III) OXIDE/FERRIC OXIDE/YELLOW FERRIC

CAS: 1309-37-1

RTECS: NO7400000

Fraction By Weight: 17%

OSHA PEL 10 MG/CUM

ACGIH TLV: 5 MG/CUM (FE)

CALCIUM CARBONATE, DOMOLITE, LIMESTONE, WHITING

CAS: 1317-65-3

RTECS: EV9580000

Fraction By Weight: 17%

ACGIH TLV: 10 MG/CUM (DUST)

ALKYD RESIN *95-1*

CAS: 66070-65-3

Fraction By Weight: 25%

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES & MUCOUS MEMBRANES,
CHEMICAL PNEUMONITIS, PULMONARY EDEMA/HEMORRHAGE & DEPRESSION OF
CENTRAL NERVOUS SYSTEM.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DRY SKIN, HEADACHE, DIZZINESS, NAUSEA, LOSS OF
CONSCIOUSNESS.
Medical Cond Aggravated by Exposure:DRY SKIN, DERMATITIS, CHEMICAL
PNEUMONITIS, PULMONARY EDEMA/HEMORRHAGE.

First Aid:EYES: FLUSH W/WATER. SKIN: WASH W/SOAP & WATER. INHALATION:
REMOVE TO FRESH AIR & PROVIDE OXYGEN/CPR IF NEEDED. INGESTION:
DON'T INDUCE VOMITING. IF VOMITING OCCURS, KEEP HEAD LOWER THAN
HIPS TO PREVE NT ASPIRATION OF LIQUID INTO LUNGS. OBTAIN MEDICAL
ATTENTION IN ALL CASES.

Flash Point Method:SCC
Flash Point:104F
Lower Limits:1
Upper Limits:7
Extinguishing Media:FOAM, CO2/DRY CHEMICAL
Fire Fighting Procedures:WEAR SCBA W/A FULL FACEPIECE OPERATED IN A
PRESSURE DEMAND/OTHER POSITIVE PRESSURE MODE WHEN FIGHTING FIRES.
DIRECT WATER STREAM MAY SPREAD BURNING PRODUCT.(SUP
Unusual Fire/Explosion Hazard:SOLVENT VAPORS ARE HEAVIER THAN AIR & MAY
TRAVEL ALONG THE GROUND & BE IGNITED AT LOCATIONS DISTANT FROM
MATERIAL HANDLING POINT.

Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES (FLARES,
FLAMES, PILOT LIGHTS, ELECTRICAL SPARKS). EVACUATE AREA UNTIL CLEAN
UP HAS BEEN COMPLETED, STOP AT SOURCE. DIKE AREA TO PREVENT
SPREADING; PUMP LIQUID INTO SALV AGE CONTAINER.

Handling and Storage Precautions:STORE MATERIAL IN TIGHTLY CLOSED
CONTAINERS AWAY FROM SOURCES OF HEAT/IGNITION; CONTAINERS SHOULD BE
GROUNDED WHEN TRANSFERRING.
Other Precautions:DON'T TRANSFER TO UNMARKED CONTAINERS. NEVER USE
PRESSURE TO EMPTY CONTAINERS; LOOSEN CLOSURES CAREFULLY. EMPTY
CONTAINERS MAY CONTAIN HAZARDOUS PRODUCT RESIDUES & CONSTITUTE
HAZARDOUS WASTE. DON'T WE AR CONTACT LENSES.

Respiratory Protection:A NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR IS
ADVISED.
Ventilation:LOCAL EXHAUST: PROVIDE SUFFICIENT TO MAINTAIN EXPOSURE <
TLV.
Protective Gloves:NITRILE RUBBER
Eye Protection:CHEMICAL SPLASH GOGGLES
Other Protective Equipment:IMPERVIOUS CLOTHING & BOOTS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. WASH W/SOAP & WATER BEFORE EATING, DRINKING, SMOKING/USE OF
FACILITYS
Supplemental Safety and Health
FIRE PROC CONT'D: USE WATER SPRAY TO COOL FIRE EXPOSED CONTAINERS,
EQUIPMENT/STRUCTURES.

Boiling Pt:B.P. Text:315-388F
Vapor Density:>1
Spec Gravity:1.172
Evaporation Rate & Reference:(ETHYL ETHER = 1): 70
Solubility in Water:INSOLUBLE
Appearance and Odor:RED LIQUID PETROLEUM W/DISTILLATE ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT/SOURCES OF IGINITION.
Hazardous Decomposition Products:CO, CO2.

Waste Disposal Methods:MATERIAL NOT USEABLE FOR ITS ORIGINAL PURPOSE &
CONTAMINATED ABSORBENT WILL BE HAZARDOUS WASTE. DISPOSE OF
IAW/FEDERAL, STATE & LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.